Sunchaser Awning Spring Tension

This method may be slightly less effective but it s easier if you have no one to help.

Sunchaser awning spring tension.

Special aluminum poles often accompany the rv awning for this use. The sunchaser has all the dometic qualities rvers have trusted for years in a full featured easy to operate manual awning at an affordable price. For more information call 5. Automatic fabric tensioning and ergonomically designed lock knobs make it a breeze to operate.

If you are satisfied move on. Now that you are going to re tension the spring it s time to insert it back after you have reinstalled the torsion assembly. Although you must trim plastic tab from inside of end cap. Push the aluminum pole in its extended length up to the rv wall and down to the lip of the awning under the awning itself.

View a complete step by step instructional tutorial for replacement of a new or damaged solera manual awning spring assembly. You do not need to put the screws back in. Easy replacement for sunchaser awning. Mark or make note of the location of the fabric and the end cap on the roller tube.

Roll the awning back up to observe how tight it is. This is necessary to reposition the new torsion fabric or roller tube exactly the same when the new part is installed. Partially or fully extend it up to 8 in either carport or patio position. Position so the pole pushes the awning out adding tension to the fabric.

If you over tighten the spring it will break. For proper awning operation the roller tube is under spring tension from the torsion assemblies. The cotter pins are the ones that lock the spring tension securely while taking down the rv awning. Place the step stool near the lip of the awning.

Dometic 3311311 000b right torsion spring for 2 step awning. Carefree 850001 white pioneer crank out rv awning upgrade endcap kit. Only rotate the legs one or two turns at a time and don t do more than 4 or 5 total. Received the new spring today.

Improper release of this spring tension can result in damage to the awning severe per sonal injury or both. If not then repeat the previous steps. Awning tension tips your awning may have arrows at the ends of the roller tube that indicate which way to rotate the arms. Some diyers prefer to adjust the tension in each arm separately rather than releasing both at the same time.

Make sure the torsion spring has been relieved of its tension see section c 2.