Solar Water Heater Maintenance Checklist

Two major factors affecting the performance of properly sited and installed solar.

Solar water heater maintenance checklist.

Also read your owner s manual. If water is milky drain entire tank. Turn off the heat. Preventing scaling and corrosion.

Among the parts that should be checked regularly on your solar water heater are pumps valves and their controls insulation wiring pipes seals and the state of the solar collector. Let the water run until it stops flowing. Drain the water from the hot water pipe. Use a solution of dish soap and warm.

Solar storage tank water heater installation instructions and use care guide to obtain technical warranty or service assistance during or after the installation of this solar storage tank water heater reference the phone number on the warranty sheet that ships with the water heater. Don t miss the temperature and pressure valves. With pressure valve still open turn on the water to the water tank and then turn on the water drain to allow the rest of the sediment to be flushed out. Satisfactory not satisfactory 2 quantity of hot water supply.

Close drain valve and open cold water supply valve. Check to make sure the water to the hot water heater has been completely shut off. Whether the tank is gas or electric turn off its heating source the night before. 1 temperature of hot water.

If it is then you are set to refill the tank. Here are some suggested inspections of solar system components. Satisfactory not satisfactory 3 constant temperature e g. When calling for assistance please have the following.

Open a hot water. Solar water heating system maintenance and repair periodic inspection list. Before you begin inspect all of the valves. Install pump onto the water heater discharge using pipe fitting.

Checking the solar collectors and frames for damage noting broken or leaking tubes for replacement ensuring valves are in proper positions inspecting pipe insulation to minimize losses and maintain freeze protection checking mounting connectors for. Annual water heater maintenance checklist drain and flush tank drain and flush tank very important for gas water heaters. Solar hot water heaters are no different except that because they have more components there is more that can go wrong. Drain 2 3 gallons of water.

Be sure to check the water draining out and make sure it is clear. Turn off cold water supply and open drain valve. If that is too. Regularly scheduled maintenance should include.

Allow a few gallons worth of water to drain.